sumitomo减速机,弗兰德减速机,重齿,南高齿-AJ亚洲国际传动设备(上海)有限公司 设为首页 - 加入收藏 - 技术博客 - 网站地图
   齿轮马达
RR系列同轴式斜齿减速机
RS系列斜齿轮-蜗轮减速机
RK系列斜齿-螺旋锥齿轮减速机
RF系列平行轴斜齿减速机
   行星减速机
RP系列行星减速机
   重载齿轮箱
RHB工业齿轮箱
RM系列大型工业减速器
   高速齿轮箱/增速箱
R高速齿轮箱/增速箱
   风电齿轮箱
R风电齿轮箱
   三相异步电动机
R三相异步电动机
您当前位置: 首页 > 新闻资讯
sumitomo减速机的润滑步骤


sumitomo减速机的润滑步骤:

Lubrication procedure of the reducer:

1、卧式sumitomo减速机在正常情况下采用油池润滑,油面高度保持在视油窗的中部即可,在工作条件恶劣,环境温度处于高温时可采用循环润滑。

1, horizontal reducer in normal circumstances, the oil pool lubrication, oil surface height to maintain the central part of the oil window can be, in poor working conditions, environmental temperature at high temperature can be used cycle lubrication.

2、sumitomo减速机在常温下一般选用40#或50#机械油润滑,为了提高减速机的性能、延长sumitomo减速机的使用寿命,建议采用70#或90#极压齿轮油,在高低温情况下工作时也可应重新考虑润滑油。

In general, 2 cycloid reducer selection No. 40 or 50 machine oil lubrication at room temperature, in order to improve the performance of reducer and prolong the service life of the cycloid reducer, recommended by the No. 70 or no. 90 gear oil, working in high temperature and low temperature conditions can also be re consider the lubricating oil.

3、立式安装sumitomo减速机要严防油泵断油,以避免减速机的部件损坏。

3, vertical installation of cycloid reducer to prevent pump off the oil, so as to avoid damage to the components of the reducer.

4、加油时可旋开机座上部的通气帽即可加油。放油时旋开机座下部的放油塞,即可放出污油。该减速机出厂时内部无润滑油。

4, when the gas can be rotated on the upper part of the air cap can be refueling. Oil drain off the lower part of the oil drain plug, you can release the dirty oil. The gear reducer has no lubricating oil at the time of leaving the factory.

5、第一次加油运转100小时应更换新油,(并将内部污油冲干净)以后再连续工作,每半年更换一次(8小时工作制),如果工作条件恶劣可适当缩短换油时间,实践证明减速机的经常清洗和换油(如3-6个月)对于延长减速机的使用寿命有着重要作用。在使用过程中应经常补充润滑油。

5, the first time on 100 hours of operation should be replaced with new oil (and internal oil rinse) after continuous work, the replacement once every half a year (8 hours), if the poor working conditions may be appropriate to shorten the time of oil, proved the reducer for frequent cleaning and oil (such as 3-6 months) have plays an important role in prolonging the life of gear reducer. In the use of the process should always add oil.


日期:2016/12/8 14:09:27
咨询QQ
点击这里给我发消息