sumitomo减速机,弗兰德减速机,重齿,南高齿-AJ亚洲国际传动设备(上海)有限公司 设为首页 - 加入收藏 - 技术博客 - 网站地图
   齿轮马达
RR系列同轴式斜齿减速机
RS系列斜齿轮-蜗轮减速机
RK系列斜齿-螺旋锥齿轮减速机
RF系列平行轴斜齿减速机
   行星减速机
RP系列行星减速机
   重载齿轮箱
RHB工业齿轮箱
RM系列大型工业减速器
   高速齿轮箱/增速箱
R高速齿轮箱/增速箱
   风电齿轮箱
R风电齿轮箱
   三相异步电动机
R三相异步电动机
您当前位置: 首页 > 新闻资讯
使用减速机的操作技巧介绍

减速机四大使用技巧:

Four major uses of speed reducer:

一、工作中,当发现油温温升超过80℃或油池温度超过100℃及产生不正常的噪声等现象时应停止使用,检查原因,必须排除故障,更换润滑油后,方可继续运转。

A work, when the temperature is higher than the temperature of 80 DEG C or oil tank temperature exceeding 100 DEG C and the noise generated abnormal phenomenon should stop using, check the reason, must remove the fault, replace the lubricating oil, can continue to operate.

二、换油时要等待减速机冷却下来无燃烧危险为止,但仍应保持温热,因为完全冷却后,油的粘度增大,放油困难.注意:要切断传动装置电源,防止无意间通电。

Two, the oil cooled combustion reducer to wait for risk, but still should keep warm, because completely cooled, oil viscosity, oil discharge difficult. Note: to cut off the power transmission device, to prevent inadvertent energizing.

三、在运转200~300小时后,应进行第一次换油,在以后的使用中应定期检查油的质量,对于混入杂质或变质的油须及时更换.一般情况下,对于长期连续工作的减速机,按运行5000小时或每年一次更换新油,长期停用的减速机,在重新运转之前亦应更换新油.减速机应加入与原来牌号相同的油,不得与不同牌号的油相混用,牌号相同而粘度不同的油允许混合使用。

In three, 200~300 hours after the operation, should first change, should regularly check the quality of oil use in the future, the impurities or deterioration of oil should be changed. In general, the reducer of continuous work, according to the operation of 5000 hours or more every year a new oil, reducer long-term disabled the re operation should be replaced with new oil. The reducer should be added with the same original grades of oil, not with different grades of oil mixture, the same as the viscosity grade of different oil mixture is allowed to use.

四、用户应有合理的使用维护规章制度,对减速机的运转情况和检验中发现的问题应作认真记录,上述规定应严格执行。

Four, the user should have a reasonable use of the maintenance rules and regulations, the operation of the reducer and the problems found in the inspection should be carefully recorded, the above provisions should be strictly enforced.


日期:2016/12/14 15:35:08
咨询QQ
点击这里给我发消息